(817) 416-8881

Dual Flare

Kimark's dual flare is designed specifically for dual stream VOC control at a 98% DRE. The flare controls low pressure (i.e., storage vessel flash) and high pressure (e.g., wellhead, separator, etc.) vapor with one footprint. With a minimum height of thirty (30) feet our smallest version can handle flow rates of 2.5 MMCFD (30 psig). At fifty (50) feet tall, our largest version is maxes out at 5 MMCFD (30 psig). With three sizes to choose from and the capability to increase the vent height, Kimark dual flares can meet company safety standards/requirements and regulatory compliance regulations.

KIMARK SYSTEMS OFFER A DUAL FLARE IN THREE (3) VERSIONS, DEPENDING ON YOUR APPLICATION. THE MORE FLOW, THE GREATER THE RADIATION; THEREFORE, THE HIGHER THE STACK MUST BE TO ENSURE A SAFE DISTANCE FROM FLAME CENTER.

 

LP (low pressure), HP (high pressure)

FEATURES

 

  • 98% Destruction Rate Efficiency (DRE)
  • Air-Assist - 1HP Motor Controlled Precisely With a VFD
  • Built-In Modbus Communications
  • Data Logging

 

 

 

  • Manual Dump Fuel Scrubber
  • Auto-Dump Main Stream (HP/LP) Scrubbers
  • Continuous Pilot / Auto-Ignition System
  • Ergonomic Access to Pilot Assembly

 

ENVIRONMENTAL COMPLIANCE

 

All Kimark and OTA equipment is designed to federal and state design, monitoring, and operational requirements. The dual flare is no different. It operates with a continuous burning pilot with a backup auto-ignition system to ensure that when vapors are present, they will be ignited. The onboard logging computer records equipment performance important from operation and regulatory standpoints. It operates in a leak free capacity with its ability to cutoff stream flow in emergency situations. The dual flare meets the standards set forth in 60.18 of the NSPS (i.e. flare tip velocity, minimum heating value, recordkeeping, etc.).

 

Dual Flare in Action VIDEO

50 PSIG of inlet pressure moving about 2 MMSCFD; 15-20 MPH wind gusts; 14-1 Turndown Ratio

Dual Flare AT NIGHT VIDEO

30 PSIG of inlet pressure moving about 5 MMSCFD; <10 MPH wind gust; 14-1 Turndown Ratio

experience + communication + innovation

= integration

© COPYRIGHT 2016 | ALL RIGHTS RESERVED

Kimark's Parent Company
Specializing in Vapor Recovery